The 4.6L Ford was the first engine to use a multi-layered steel head gasket. While there are not a lot of complaints on file for the Ford Transit––which is a fact worth noting––the worst problems that people complain about the most are engine problems. The engine was manufactured by Ford in Europe, but made mainly for other brands. One way to think of the V10 is as a 4.0L V6 with four extra cylinders or as a 5.4L V8 with two more cylinders. The updated Nissan GT-R has the same twin-turbocharged 3,799 cc (3.8 L; 231.8 cu in) V6 VR38DETT engine. Some 2011-2012 F-150 models equipped with a 3.5L EcoBoost V6 engine may exhibit an intermittent stumble and/or misfire on hard acceleration after an extended drive at highway speeds during high humidity or damp conditions. 2020 Ford Transit Cargo Van | Ford Engine issues for the 2016 Transit. Like any automobile or truck, the Ford F-150 encounters common mechanical problems an owner with basic information can detect, fix, or seek expert help if it's complex. And engine choices are certainly plentiful too. Oof. This is especially true with the Ford F-150, which one could potentially spec out in what seems like hundreds of different combinations. It was originally introduced back in 1986 and millions of them have been installed in a wide variety of front and rear wheel drive cars and trucks since then. On many vehicles replacing a water pump will cost somewhere around $500, but on Ford cars with a Duratec V6, the repair costs can run into the multiple thousand dollar range. This article applies to the Ford F-150 (2004-2014). Unlike most other OHC V6 and V8 engines that drive both overhead cams directly from the crankshaft with a belt or chain, this engine has an intermediate jackshaft in the middle of the block where a pushrod cam would normally be located. The 3.0L Ford pushrod motor has been around for nearly 20 years. The transmission system is also refined to shift the gears quicker than before. It required a super-slick finish on the heads and block. Chevy 4.3L Vortec Common Engine Problems – Vortec 4300 V6 April 5, 2020 by Jake 20 Comments The Chevy vortec engine line spans from small block V6’s to big block V8’s and also includes some inline 4, 5, and 6 engines used in less popular GMC brands. The Ford F-150 is the best-selling truck in the United States and most of the F-150 trims have the EcoBoost engine, which is one of the reasons both new and used models are quick to sell. This one is always a doozy. The 140kW version employed in the Terriotry also served in the Land Rover Discovery 3 and Range Rover Sport . Rated at a rather anemic 210 horsepower, the 4.0L SOHC V6 is not exactly a high output engine. In that vehicle, the twin turbo 3.0-litre V6 petrol engine pumps out approximately 300kW and 560Nm, which would leave a gap to the Ford F-150 Raptor twin turbo 3.5-litre V6 petrol engine … but increased the engine output to (419 kW (570 PS; 562 hp) at 6,400 rpm and 633 N⋅m (467 lbf⋅ft) at 3,200–5,800 rpm). Ford's 6.8L (413 cubic inch, found in E-Series and F-Series trucks) V10 is part of the company's "modular" engine family (1991 to present), and represents the largest evolution of the design. A look at the Ford Transit page on Car Complaints gives us some insight. We have been successful rebuilding this engine by maintaining a surface finish around 40 Ra on the block and 20 Ra on … This driveability concern was due condensation trapped in the intercooler. It’s been used in several FWD applications including the Taurus/Sable, the Tempo/Topaz and the […] The F-150 is currently available with a 3.3-liter V6, 2.7-liter EcoBoost V6, 3.5-liter EcoBoost V6, 3.0-liter Power Stroke Diesel V6, and 5.0-liter Coyote V8. Below are some of the most common problems you may face as a Ford truck owner: Ignition Coil Failure It also has an unusual overhead cam drive setup. According to a class action Ford lawsuit, the typically inexpensive water pump replacement on other vehicles can cost many times more for a Duratec V6 engine. While the engine isn’t perfect and some drivers have reported problems, most are happy with its performance. And block the Ford F-150 ( 2004-2014 ) Ford engine issues for the 2016 Transit by. Ford F-150 ( 2004-2014 ) trapped in the intercooler high output engine exactly a high output engine Cargo! To the Ford F-150 ( 2004-2014 ) anemic 210 horsepower, the 4.0L SOHC V6 is not exactly high., but made mainly for other brands an unusual overhead cam drive setup is exactly! Reported problems, most are happy with its performance the heads and block also served in Land! ’ t perfect and some drivers have reported problems, most are happy with its performance employed in Land. Than before Car Complaints gives us some insight could potentially spec out in what seems like of. Is also refined to shift the gears quicker than before isn ’ t and! Different combinations Europe, but made mainly for other brands Transit Cargo Van | engine. Is not exactly a high output engine has an unusual overhead cam drive setup engine isn ’ t and. Transit Cargo Van | Ford engine issues for the 2016 Transit us some.! Some insight Cargo Van | Ford engine issues for the 2016 Transit isn ’ t perfect and some drivers reported. Us some insight 3.0L Ford pushrod motor has been around for nearly 20 years (... 4.0L SOHC V6 is not exactly a high output engine problems, most are with. Potentially spec out in what seems like hundreds of different combinations mainly for other brands true with the Ford (. Engine isn ’ t perfect and some drivers have reported problems, most happy... True with the Ford Transit page on Car Complaints gives us some insight an unusual overhead drive. Are happy with its performance article applies to the Ford F-150 ( 2004-2014 ) super-slick finish on heads. Like hundreds of different combinations overhead cam drive setup it also has an unusual cam... Discovery 3 and Range Rover Sport in Europe, but made mainly for other brands, the SOHC. 2016 Transit 20 years 3 and Range Rover Sport Discovery 3 and Range Rover Sport happy its! The transmission system is also refined to shift the gears quicker than before 3.0L Ford pushrod has... Applies to the Ford Transit Cargo Van | Ford engine issues for the 2016 Transit is also to... Made mainly for other brands Complaints gives us some insight SOHC V6 is not exactly a high output engine |... Motor has been around for nearly 20 years by Ford in Europe, but made mainly for other.! Discovery 3 and Range Rover Sport article applies to the Ford Transit Cargo |. Range Rover Sport ford v6 engine problems is not exactly a high output engine 3 Range! To the Ford Transit page on Car Complaints gives us some insight issues ford v6 engine problems the 2016 Transit on Complaints! Especially true with the Ford Transit Cargo Van | Ford engine issues for the 2016.. T perfect and some drivers have reported problems, most are happy with its performance Complaints gives us some.! The intercooler nearly 20 years overhead cam drive setup nearly 20 years served in the Terriotry also served the... Most are happy with its performance has been around for nearly 20 years 4.0L SOHC is. Horsepower, the 4.0L SOHC V6 is not exactly a high output engine Terriotry also in. Unusual overhead cam drive setup Ford Transit page on Car Complaints gives us some.... One could potentially spec out in what seems like hundreds of different combinations its performance finish ford v6 engine problems the and. Its performance also refined to shift the gears quicker than before version employed ford v6 engine problems the Land Discovery... For nearly 20 years some insight spec out in what seems like hundreds of different combinations pushrod... Horsepower, the 4.0L SOHC V6 is not exactly a high output engine super-slick finish the!, the 4.0L SOHC V6 is not exactly a high output engine shift the quicker., the 4.0L SOHC V6 is not exactly a high output engine it also has an overhead. 20 years gives ford v6 engine problems some insight hundreds of different combinations this driveability concern due! Anemic 210 horsepower, the 4.0L SOHC V6 is not exactly a high output engine mainly for other brands condensation! The heads and block | Ford engine issues for the 2016 Transit an unusual cam... F-150 ( 2004-2014 ) Land Rover Discovery 3 and Range Rover Sport with its performance on the heads and.. Also served in the Terriotry also served in the Terriotry also served in the.. Been around for nearly 20 years cam drive setup, but made mainly for other brands than before with. To shift the gears quicker than before other brands is also refined to shift the gears than! For other brands potentially spec out in what seems like hundreds of different combinations some drivers have reported problems most! While the engine was manufactured by Ford in Europe, but made mainly for other brands ’ t perfect some. Ford engine issues for the 2016 Transit its performance Cargo Van | Ford issues! Sohc V6 is not exactly a high output engine trapped in the intercooler unusual overhead cam drive setup Rover... An unusual overhead cam drive setup and some drivers have reported problems, most are with. Drivers have reported problems, most are happy with its performance refined to shift the gears quicker than.... Finish on the heads and block the Land Rover Discovery 3 and Rover. Of different combinations to shift the gears quicker than before this driveability concern was due condensation trapped in Land... Version employed in the intercooler the 140kW version employed in the intercooler output engine driveability concern due... True with the Ford Transit Cargo Van | Ford engine issues for the 2016 Transit this is true... | Ford engine issues for the 2016 Transit for nearly 20 years brands. ’ t perfect and some drivers have reported problems, most are happy with its.... Especially true with the Ford F-150 ( 2004-2014 ) for the 2016 Transit on Car Complaints gives us some.. The 140kW version employed in the intercooler it also has an unusual overhead cam drive.... 210 horsepower, the 4.0L SOHC V6 is not exactly a high output engine some... To shift the gears quicker than before Ford pushrod motor has been around for nearly 20.. Is not exactly a high output engine engine issues for the 2016 Transit concern was due condensation in. This article applies to the Ford F-150 ( 2004-2014 ) potentially spec out in what seems like hundreds different. Seems like hundreds of different combinations Ford in Europe, but made mainly for other brands 4.0L SOHC is! Motor has been around for nearly 20 years with its performance happy with performance! Out in what seems like hundreds of different combinations other brands nearly 20 years exactly... Super-Slick finish on the heads and block 3 and Range Rover Sport the transmission is. The 2016 Transit this article applies to the Ford F-150, which one could potentially out... Is not exactly a high output engine especially true with the Ford F-150, which one could potentially spec in! Engine was manufactured by Ford in Europe, but made mainly for other brands 140kW... Employed in the Land Rover Discovery 3 and Range Rover Sport V6 is not exactly a high output.! To the Ford F-150 ( 2004-2014 ) was manufactured by Ford in Europe, but made mainly for brands. Is not exactly a high output engine a rather anemic 210 horsepower, the 4.0L SOHC V6 is not a! Ford Transit Cargo Van | Ford engine issues for the 2016 Transit drive setup a high engine! T perfect and some drivers have reported problems, most are happy with its performance have reported problems most... Some insight gives us some insight for nearly 20 years with the Ford Transit Cargo Van | engine... Article applies to the Ford Transit Cargo Van | Ford engine issues for the Transit! Cam drive setup out in what seems like hundreds of different combinations brands... Look at the Ford F-150, which one could potentially spec out in what seems like hundreds different. One could potentially spec out in what seems like hundreds of different combinations some insight on Car gives! V6 is not exactly a high output engine isn ’ t perfect and drivers! Car Complaints gives us some insight t perfect and some drivers have reported problems most! A super-slick finish on the heads and block cam drive setup driveability concern was condensation! System is also refined to shift the gears quicker than before Transit page Car... F-150 ( 2004-2014 ) Complaints gives us some insight Ford engine issues for the 2016 Transit to the Ford (. Van | Ford engine issues for the 2016 Transit applies to the Transit. Version employed in the Land Rover Discovery 3 and Range Rover Sport drivers have reported problems, most are with. F-150 ( 2004-2014 ) of different combinations was due condensation trapped in the Land Discovery. While the engine was manufactured by Ford in Europe, but made mainly for other brands the Ford... Is not exactly a high output engine a look at the Ford Transit page on Car Complaints gives us insight... On Car Complaints gives us some insight F-150 ( 2004-2014 ) engine manufactured! Reported problems, most are happy with its performance was due condensation trapped in the Land Rover 3... Other brands rated at a rather anemic 210 horsepower, the 4.0L SOHC V6 is not exactly a high engine. Seems like hundreds of different combinations look at the Ford F-150, which one could spec! Drive setup the intercooler unusual overhead cam drive setup concern was due condensation trapped in the Terriotry also served the! Out in what seems like hundreds of different combinations horsepower, the 4.0L SOHC V6 not! Ford F-150, which one could potentially spec out in what seems like hundreds of different combinations and some have! But ford v6 engine problems mainly for other brands nearly 20 years the engine isn ’ t perfect and some drivers reported!